EN  /  中文版

Gasification Power Plant

Home > Products > Gasification Power Plant
Gasification Power Plant
Gasification Power Plant
Gasification Power Plant

Gasification Power Plant

Share:
  • Feature
  • Application
  • Fuel
  • Basic principle
  • Working principle

PRODUCT FEATURE

1.The gasifier uses fixed bed down-draft type, produce syn-gas continuous and stably with low tar content, it can generate electricity continuous.

2.Easy to use and operate, use Siemens PLC touch screen control panel to realize automatic control and semi-automatic control. Independent operation room, adjust parameter directly by controlling LCD touch screen. Then gen set will operate with separately control system.

3.Due to MSW gasification process adopts pyrolysis and accurate control in different stage, so it can reach specified flue gas standard.

4.Due to low temperature gasification combustion(gasifier furnace) under anaerobic condition and low temperature gasifier and combustion, only producing combustible gas, particulate matter emission is precious little.

5.Finish low temperature oxidation process in high temperature combustion chamber (combustion furnace), not producing harmful gas secondary pollution.

6.Due to combustion process is complete, the ash is completely non- pollution matter.

7.The removal rate of organic is over 90%, so it reduce the follow-up treatment cost greatly.

8.All kinds of waste with different composition can burn stably at the same time.

9.Safety separation combustion, restrict dioxin and other harmful matter output.

10.Operation 24 hours/day continuous.

11.Waste need to sort out, and improved operation efficency, ensure the safety of working environment.

12.Haiqi gasification system is fully closed, it is neat and beautiful look at site, no harmful to operation people. Automatic fuzzy control, easy to operate. All fuel feeding, slag discharge door, overhaul hole use soft seal, On the top of furnace has a seal cover to avoid gas leakage. The sealing of furnace is good, realizing good effect of oxygen controlling and pyrolysis.

13.When pyrolysis gas spontaneous combustion take place, then it enter into a process of spontaneous combustion, auxiliary combustion device will stop automatically. The whole process of spontaneous combustion is over 90%, greatly lower running cost. Realized resource utilization of waste thermal energy. Flue gas emission is no harmful and total CO2 emission is reduced.

Gen set: the gas from biomass and MSW is syn-gas, the components of the syn-gas is special, the impurity content is too much, so Haiqi company adopts large cylinder, lower rotate speed internal combustion engine, generate electricity stably.

tu1.jpg

APPLICATION SCOPE

Use all kinds of agriculture waste, city waste and industry waste to generate electricity, supply to factory or connect with national grid.

Gasification Power Plant

Fuel

Wood Chips, Rice Husk, Palm Shell, Coconut Shell, and all kinds of agricultual & forestry waste, houshold waste, industrial waste, medical waste, etc...

Raw Material Required: Moisture≤15%
Size : 3-10cm

Gasification Power Plant Gasification Power Plant Gasification Power Plant


Basic principle

ModelHQ-100HQ-200HQ-300HQ-400HQ-500HQ-600HQ-800HQ-1000HQ-1200
Rated Power10020030040050060080010001200
Rated Frquencey50/60 HZ
Rated Voltage(V)220/400/440/6300/6600/11000/13800
Mode of GasifierHQ-100HQ-200HQ-300HQ-400HQ-500HQ-600HQ-800HQ-1000HQ-1200
Gasifier TypeDraft Down Fixed Bed Gasifier
Biomass Moisture Requirement≤20%(Wet Basis)
Biomass Size Requirement10mm-100mm
Biomass Consumption (Kg/Hr)120-150240-300360-450480-600600-750720-900960-12001200-15001440-1800
Gas Production (Nm3/h)250-300500-600750-9001000-12001250-15001500-18002000-24002500-30003000-3600
Ash Discharge TypeWet Type or Dry Type
Type of Gas PurificationWet Type or Dry Type Gas purification System
Heat Value of Gas> 1,100-1300Kcal/Nm3
Gas CompositionCO -19±3% H2 -18±2% CO2 - 8±3% CH4 -6±2% N2 -50%
Model of Genset100GFT250GFM300GFM400GFM500GFM600GFM400GFM500GFM600GFM
Qty of Genset1 Set1 Set1 Set1 Set1Set1 Set2 Sets2 Sets2 Sets
Contact Us

Shangqiu Haiqi Machinery Equipment Co., Ltd.

E-mail: Steven@haiqimachine.com

QQ: 2850962808

Skype: jessehaiqi

Whatsapp: +86 133 0370 1551

Tel.: +86 370 2876 182

Follow Us

Copyright © Shangqiu Haiqi Machinery Equipment Co., Ltd. All Rights Reserved   Powered by  

Top